Alto 91WS Betreibershandbuch

AMERICAN-LINCOLNTECHNOLOGYOperator's Manual91WSWalkbehindSweeperBeginning withSerial No. 306005READ THIS BOOK!All directions given in this book a

American-Lincoln 1 - 991 WSMACHINE CONTROLSKEY SWITCHThe key switch is a two position rotary ON/OFF switch that is located on the control panel.The fi

American-Lincoln 3-1591 WSAMERICAN-LINCOLN91WS WALK BEHIND MACHINE“BUMPER-TO-BUMPER” LIMITED WARRANTYI. COVERAGEA. Subject to the terms and

1-10 American-Lincoln91 WSSTART BUTTON (Gas/LP Only)The start button is located on the right side of the console next to the key switch. The start but

American-Lincoln 1 - 1191 WSSIDE BROOM LIFT HANDLEThe Side Broom lift handle is located at the rear of thesweeper on the right side. The lift handle r

1-12 American-Lincoln91 WSFILTER MANIFOLD LATCHThe filter manifold latch is located on the hinged filtermanifold assembly. The latch must be disengage

American-Lincoln 1 - 1391 WSCIRCUIT BREAKERSThe circuit breakers provide protection for the electricalsystem and are located on the console. The circu

1-14 American-Lincoln91 WSBATTERY MACHINE OPERATIONCharge the batteries after operating the machine. See the battery charging instructions in this man

American-Lincoln 1 - 1591 WSSTARTING INSTRUCTIONSPRE-START CHECKLISTBefore starting the machine, do these pre-start checks.1. Check all controls for p

1-16 American-Lincoln91 WSTO DRIVE MACHINE FOR TRANSPORTUse these instructions to drive the machine for transport to the sweeping site.WARNING Be care

American-Lincoln 1 - 1791 WSPOST OPERATION CHECKLISTAfter stopping the machine perform these post operation checks. 1. Check sweeping brooms for wear

1-18 American-Lincoln91 WSTO CHARGE THE MOTIVE POWER BATTERIES (Battery powered machines only)1. Read the detailed instructions provided on the charge

American-Lincoln 1 - 191 WSMACHINE SPECIFICATIONS ...

American-Lincoln 1 - 1991 WSTO CHANGE LP TANKThe tank changing operation presents an opportunity for the operator to inspect the tank, tank fittings a

1-20 American-Lincoln91 WSSERVICE CHART The following is a guide for servicing and maintaining your 91WS Walkbehind Sweeper. For best machineperforman

American-Lincoln 1 - 2191 WSCB-1CB-2CB-2FILTERSHAKERFILTERSHAKERBATTERYCONDITIONBATTERYCONDITIONCHECK WHILE OPERATINGCHECKWHILEOPERATINGOFFOFFOFFOFFON

1-22 American-Lincoln91 WSHOW TO SWEEPThe sweeper is intended for use on hard relatively flat surfaces such as cement, asphalt and wood block floors.E

American-Lincoln 1 - 2391 WSTO LOWERBROOMC0613/9705MAIN BROOMADJUSTMENTTO RAISEBROOMMAIN BROOMTo prevent the main broom from setting in one direction

1-24 American-Lincoln91 WS2314CO622frTO REPLACE THE MAIN BROOMThe main broom should be replaced when the bristles become worn to less than 2". Th

American-Lincoln 1 - 2591 WSSIDE BROOMSThe side broom’s sweeping angle is not adjustable, however the height of the side brooms can be adjusted tocomp

1-26 American-Lincoln91 WS TO CHANGE THE SIDE BROOMSChange the side brooms when the bristles become worn to less than 3 inches length.1. Park machine

American-Lincoln 1 - 2791 WSFLAP SERVICE INSTRUCTIONSThe flaps are very important to the sweeping process. Inspect the flaps daily and replace any fla

1-28 American-Lincoln91 WSWARNINGTo prevent accidental starting, remove spark plug wire when servicing engine or equipment. Disconnect thebattery at t

1-2 American-Lincoln91 WSTO CHANGE THE PANEL FILTER...

American-Lincoln 1 - 2991 WSTO CHECK THE ENGINE OIL LEVELBe sure the correct engine oil level is maintainedby checking the oil level daily. Use the di

1-30 American-Lincoln91 WSSERVICE INSTRUCTIONSDRIVE SYSTEM SERVICE INSTRUCTIONS - Cont.TO REPLACE THE REVERSE BELT1. Remove the two (2) inspection plu

American-Lincoln 1 - 3191 WSLP SAFETY PRECAUTIONSWARNINGKeep cigarettes, sparks, and open flame away when working on LP equipment when inspecting for

1-32 American-Lincoln91 WSLP GAS COMPONENTSFUELLOCK/FILTERTANK RELIEF VALVETANK VALVELPG FUEL TANKPRESSURE RELIEF VALVEREGULATOR/VAPORIZERCARBURETORP4

American-Lincoln 1 - 3391 WSLP GAS COMPONENTSLPG INLETHAND PRIMER PINPLUGVAPOROUTLETP-4563AWATERMOUNTING HOLESP4563 FIGURE 22LP CHECKLISTThis checklis

1-34 American-Lincoln91 WSLP TANK CAREUSE AND CARE OF LP TANKSIf an LP tank is damaged or leaking, it should be immediately removed to a designated sa

American-Lincoln 1 - 3591 WSSTANDARD METRIC TORQUE VALUESWhen tightening torques are not specified, tighten the bolts and nuts according to the table

1-36 American-Lincoln91 WSFRACTION FRACTIONDECIMAL DECIMALMILLIMETER MILLIMETERC-2001/9907DECIMAL METRIC & CONVERSION TABLE

American-Lincoln 1 - 3791 WSSAE - Grade 5SAE - Grade 8ScrewSizeGrade5PlatedGrade8Plated410HStainlessBrassTypeF&T&BTTypeB, AB*6*8*10*1/45/163/8

1-38 American-Lincoln91 WSABBREVIATIONS - SCREWSADJ= Adjusting ScrewADJ.SP= Adjusting Plunger ScrewBHM= Binding Head Machine ScrewBHS= Button Head Soc

American-Lincoln 1 - 391 WSSWEEPING PATH 36 inches (91.44 cm) with single side broom45 inches (114.30 cm) with dual side broomTRAVEL SPEED 0-3 m.p.h.D

American-Lincoln 1 - 3991 WSKey No. Part Number DescriptionH1 2-00-05060 Screw, #6-32 x 1.250 RHMH2 2-00-00455 Flat Washer, .375 x .156 x .047H3 2-00-

1-40 American-Lincoln91 WSKey No. Part Number DescriptionH63 2-00-02312 Lock Washer, 1/2 HS Med.H64 2-00-00596 Nut, Hex. 1/2-13 x .750 x .437H65 2-00-

American-Lincoln 1 - 4191 WSH125 2-00-00418 Flat Washer, .984 x .627 x .063H126 2-00-03466 Screw, #10-16 x .500H127 2-00-03522 Washer, 5/16 x 1.250 x

1-42 American-Lincoln91 WSKey No. Part Number DescriptionH187 2-00-00071 Screw, #10-24 x 1.250 RHMH188 2-00-01987 Flat Washer, .438 x .200 x .036 sstH

American-Lincoln 1 - 4391 WSH243 2-00-00591 Nut, Hex-Jam .50-20H244 2-00-05297 Nut, Insert Fiber, .38-16 Heavy NutH245 2-00-05401 Shoulder Screw, 1/2-

1-44 American-Lincoln91 WSKey No. Part Number DescriptionH305 2-00-00809 Screw, HSHC .31 - 18 x 1.00H306 2-00-05405 Nut, 3/8 - 32 NEF 2AH307 2-00-0296

American-Lincoln 1 - 4591 WS®®MODEL NO.SERIAL NO.Manufactured ByAMERICAN LINCOLNTECHNOLOGYBOWLING GREEN, OHIOParts may be ordered from American-Lincol

1-46 American-Lincoln Technology91 WSNOTES

American-Lincoln 2-191 WSFrame ...

2-2 American-Lincoln91 WSKEY NO. PART NUMBER DESCRIPTION QTY1 8-52-00179 Broom Door 12 8-41-00040 Latch 13 8-25-08205 Flap, R.H. Side 14 8-13-07127 Do

1-4 American-Lincoln91 WSSWEEPING SYSTEMType Direct ThrowMain BroomOne place plastic core disposable type. No tool charge. Position can be set to “R

American-Lincoln 2-391 WSH136H136H136H46C1175-1/9604H43H35H26H26H27H15H136H136H86FRAME - EXPLODED VIEW

2-4 American-Lincoln91 WSKEY NO. PART NUMBER DESCRIPTION QTY1 8-32-00050 Hinge 22 8-16-07358 Rear Cover 13 8-10-00027 Cable 14 8-16-07415 Cover (24VDC

American-Lincoln 2-591 WSH14H136H27H26H15H26H141H12H8H93H26H25H9C1175-2-9604COVERS - EXPLODED VIEW

2-6 American-Lincoln91 WSKEY NO. PART NUMBER DESCRIPTION QTY.1 8-23-03067 Washer, Fwd/Rev Outer 12 8-03-04312 Arm, Forward/Reverse 13 8-23-03066 Washe

American-Lincoln 2-791 WSH46H43H139H38H62H59H52H137H52H52H65H62H146H26H34H79H12H112H46H76C1176-3/0103WHEEL DRIVE - EXPLODED VIEW

2-8 American-Lincoln91 WSKEY NO. PART NUMBER DESCRIPTION QTY.1 0885-086 Differential 12 8-08-00800 Bracket, Differential Bearing 13 2-00-03997 Bearing

American-Lincoln 2-991 WSH134H62H62H140H141H15H62H65H144H143H52H82H48H102H12H46H36H43H46H146H52H140H141H15H9H62H146H142H131C1176

2-10 American-Lincoln91 WSKEY NO. PART NUMBER DESCRIPTION QTY1 8-81-00176 Main Broom Arm Support 123 7-39-00025 Knob 14 2-00-02049 Bearing 25 7-60-001

American-Lincoln 2-1191 WSH146H146H33H144H144H149H120H48H36H49H65H65H37H125H125H125H147H125H43H46H52H54H52H46 H43H34H148H148C117

2-12 American-Lincoln91 WSKEY NO. PART NUMBER DESCRIPTION QTY.1 8-70-05291 Broom Shaft 12 8-03-04311 Arm, Broom (R.H.) 13 8-03-04310 Arm, Broom Idler

American-Lincoln 1 - 591 WSMACHINE PREPARATIONYour American-Lincoln Technology sweeper has been shipped complete, but do not attempt to operate before

American-Lincoln 2-1391 WSC1177-1H61H141H14H65H145H44H33H125MAIN BROOM ARMS - EXPLODED VIEW

2-14 American-Lincoln91 WSKEY NO. PART NUMBER DESCRIPTION QTY1 8-03-04313 Side Broom Arm (Welded) 12 0885-087 Gear Box Assembly 13 8-08-03215 Side Bro

American-Lincoln 2-1591 WSC-1182H46H36H62H150H43H43H37H20H16H46H46H135H36H128H150H40H27H26H22H46H26H25H135BELT DIAGRAM1317121116

2-16 American-Lincoln91 WSKEY NO. PART NUMBER DESCRIPTION QTY.1 8-32-06103 Hopper (Plastic) 12 8-13-07130 Clamp - Filter (Rear) 13 8-13-07131 Clamp -

American-Lincoln 2-1791 WSH27H27H27H27H27H8H12H26H26H26H26H126H126H100H15H15C1178/9705HOPPER - EXPLODED VIEW

2-18 American-Lincoln91 WSKEY NO. PART NUMBER DESCRIPTION QTY.1 8-24-04140 Manifold, Filter 12 8-08-00817 Filter Manifold Bracket 13 8-08-00819 Filter

American-Lincoln 2-1991 WSC1179-1/9907H868H27H26H26H2712H86910H2871176H11H10H1516H27H263H26H86H26H25H20113H1265H6H13617144152FIL

2-20 American-Lincoln91 WSKEY NO. PART NUMBER DESCRIPTION QTY.1 8-16-07392 Plate Impeller Cover 12 8-81-00172 Support, Impeller 13 8-70-05296 Impeller

American-Lincoln 2-2191 WSH26C1179-2/9610REAR COVERH46H43H36H35APPLY NEVER - SIEZEH48H52H26H27H141H169H17H46H43BELT DIAGRAM19181

2-22 American-Lincoln91 WSKEY NO. PART NUMBER DESCRIPTION QTY1 8-81-00175 Battery Support (Welded) 12 8-81-00174 Motor Support 13 8-75-01204 Battery S

1-6 American-Lincoln91 WSBATTERY POWERED MACHINESThe battery powered machines may be shipped with the batteries and charger in separate containers. T

American-Lincoln 2-2391 WSH46H43H11H9H2H12H5H27H90H8H1H27H52H4H12H43H46H26H90H90H128H15H144H149H26H62H52H162H163H46H131H161C1187

2-24 American-Lincoln91 WSKEY NO. PART NUMBER DESCRIPTION QTY1 0877-057 Engine, 8 H.P. 12 8-51-05017 Battery Pan 13 0775-117 Battery, 12 Volt 14 8-60-

American-Lincoln 2-2591 WS1615987612410H49H52H35H52H120H48H82H129H46H144H39H151H33H144H43H120H62H131591417H26H13211323H144H46STA

2-26 American-Lincoln91 WSKEY NO. PART NUMBER DESCRIPTION QTY1 2-00-04345 Tie Raps 72 0775-159 Diode Assembly 13 0875-118 Connector Assembly, 24 VDC 1

American-Lincoln 2-2791 WSOFFOFFFILTER SHAKERCB-1CB-2ONMMABSGIBACK WIRING VIEWTOPPOWER PANELBOTTOM VIEWM1 RELAY123485308687WIRE

2-28 American-Lincoln91 WSKEY NO. PART NUMBER DESCRIPTION QTY1 2-00-04345 Tie Raps 72 2-00-04584 Terminal, .156 Female Bullet 13 2-00-04578 Terminal,

American-Lincoln 2-2991 WSOFFOFFCHOKELOW OILFILTER SHAKERCB-1CB-2STARTONMMABSGIBACK WIRING VIEWTOPBOTTOM VIEWM1 RELAY8 HP B&

2-30 American-Lincoln91 WSKEY NO. PART NUMBER DESCRIPTION QTY1 8-33-05126 Control Housing 12 8-64-00015 Shaker Timer Motor 13 8-64-00007 Circuit Break

American-Lincoln 2-3191 WSH12H9H46H26H15H103H34H43C1180/9604CONTROL PANEL (BATTERY) - EXPLODED VIEW

2-32 American-Lincoln91 WSKEY NO. PART NUMBER DESCRIPTION QTY1 8-33-05126 Control Housing 12 8-64-00015 Shaker Timer Module 13 8-64-00007 Circuit Brea

American-Lincoln 1 - 791 WSSAFETY PRECAUTIONSThe following statements are used throughout this manual as indicated in their descriptions:DANGER To wa

American-Lincoln 2-3391 WSH103H15H27H26H46H43H34H144H9H12C1181CONTROL PANEL (GAS) - EXPLODED VIEW

2-34 American-Lincoln91 WSKEY NO. PART NUMBER DESCRIPTION QTY1 8-18-00509 Instrument Panel 12 8-18-00488 Main Broom Pressure 13 8-18-00489 Vacuum Bypa

American-Lincoln 2-3591 WS46810111315714151516212217201720181923129C1183-2/1003DECALS - EXPLODED VIEW

2-36 American-Lincoln91 WSNOTES

American-Lincoln Technology 2-3791 WSCHOKESTARTCB-1 CB-2FILTER SHAKEROFFOFFONFLOATSWEEPUPMAINBROOMMAINBROOMWARNINGUNEXPECTED MOVEMENT COULD

2-38 American-Lincoln Technology91 WSNOTES

American-Lincoln 3-191 WSLeft Hand Side Broom Option ...

3-2 American-Lincoln91 WS OPTION 0880-625KEY NO. PART NUMBER DESCRIPTION QTY1 8-03-04313 Side Broom Arm (Welded) 12

American-Lincoln 3-391 WSH46H135H26H26H26H27H26H26H86H86H16H43H46H39H39H46H128H135H131H86H135C0624LEFT HAND SIDE BROOM OPTION - EXPLODED VIE

3-4 American-Lincoln91 WSKEY NO. PART NUMBER DESCRIPTION QTY1 2-60-02296 Hydrostatic Relief Valve 12 * Rubber Cap, 1/2" I.D. 13 * Fitting, 1/4 NP

1-8 American-Lincoln91 WSWARNINGDo not use this machine as a step or furniture.WARNINGBe careful when operating the machine on a ramp or incline. Alwa

American-Lincoln 3-591 WSC0625/9610EXISTINGADAPTORTO FUELPUMPREMOVEEXISTINGCARBURETORAND REPLACEWITH #22H132H150221814121313117820315H150262

3-6 American-Lincoln91 WS123456C0626FOAM FILLED TIRE OPTIONOPTION 0880-626KEY NO. PART NUMBER DESCRIPTION QTY1 0860-581 Wheel Assembly, Foam Filled 22

American-Lincoln 3-791 WSH170C1168/9510H169WET SWEEP BYPASS OPTIONKEY NO. PART NUMBER DESCRIPTION QTY1 8-16-07380 Cover, Impeller (Welded) 1

3-8 American-Lincoln91 WS0880-640 (BATTERY MACHINE)KEY NO. PART NUMBER DESCRIPTION QTY.1 8-25-08205 Flap, Door 12 8-25-08204 Flap, Rear Outside 13 8-2

American-Lincoln 3-991 WSMAIN BROOM OPTIONSKEY NO. PART NUMBER DESCRIPTION QTY.1 8-08-03222 Nylon 12 8-08-03216 Proex (Standard) 13 8-08-032

3-10 American-Lincoln91 WSSCHEMATIC & CONNECTION DRAWING - BATTERYC1188CCCC24 VOLTBATTERY BANKCB-210 AMPCB-110 AMPM13087SHAKER MOTORSHAKER MOTORRE

American-Lincoln 3-1191 WSSCHEMATIC & CONNECTION DRAWING - GAS12V BATTERYSSTARTER MOTORSHAKER MOTORIGNITIONCOIL10 AMPCHARGECOILREG.SPARK

3-12 American-Lincoln91 WSBATTERY ...

American-Lincoln 3-1391 WSHOPPER, TO EMPTY.......

3-14 American-Lincoln91 WSINDEXREPLACING THE FORWARD DRIVE BELT ...................1-29REPLAC